9193永利链接-首頁(欢迎您)

服务热线电话

400-6188-756

超声波清洗机的功率选择

来源:/ 时间: 2022-06-11 浏览次数: 2

选择超声波清洗机时,通常是输出功率。一般来说,超声波清洗的实际效果并不一定与输出功率乘以清洗时间成正比。
When selecting an ultrasonic cleaner, it is usually the output power. Generally speaking, the actual effect of ultrasonic cleaning is not necessarily proportional to the output power multiplied by the cleaning time.
如果选用的超声波清洗机输出功率比较小,即使是长时间使用,也不会完全消除污渍,如果选择的输出功率较大,虽然可以在短的时间内快速去除污渍,但也会给被清洗的对象造成一定的损失。所以选择超声波清洗机,一定要选择合适的输出功率。
If the output power of the selected ultrasonic cleaner is relatively small, even if it is used for a long time, it will not completely eliminate the stains. If the output power is large, it can quickly remove the stains in a short time, but it will also cause certain losses to the cleaned objects. Therefore, when choosing the ultrasonic cleaning machine, we must choose the appropriate output power.
当输出功率过大时,清洗缸底部的振动板空化比较严重,而且水点腐蚀也会扩大,如果选择三氯乙烯等溶剂,可能问题不大,但如果选择的是水或水溶性清洗液,那么它就会遭受水点侵蚀。
When the output power is too large, the vibration plate at the bottom of the cleaning cylinder is seriously cavitating, and the water point corrosion will also expand. If trichloroethylene and other solvents are selected, it may not be a problem, but if water or water-soluble cleaning fluid is selected, it will suffer from water point corrosion.
总之,在选择超声波清洗机时,选择和匹配输出功率,这样才能保证清洗效果。
In short, when selecting the ultrasonic cleaning machine, select and match the output power, so as to ensure the cleaning effect.
超声波清洗机一直以来清洗效果显着,操作方便受到大家的青睐。但你可能刚刚听说过这个设备,它是如何工作的,它是如何工作的,没有任何意义。那么下面小编就为大家介绍一下这款超声波清洗机的功率和频率是如何选择的,一起来看看吧。
The ultrasonic cleaning machine has been widely used for its remarkable cleaning effect and convenient operation. But you may have just heard about this device. How it works, how it works, doesn't make any sense. So the following small series will introduce to you how to choose the power and frequency of this ultrasonic cleaning machine. Let's have a look.
超声波清洗机
Ultrasonic cleaning machine
1当功率过大时
1 when the power is too large
超声清洗机功率较大时,声强变大,空化泡半径和起始半径变大,空化强度增强。即声强越高,空化越强,有利于清洗。但不是功率越大,清洗效果越好,而是正确合理地选择超声波功率。
When the power of the ultrasonic cleaning machine is high, the sound intensity increases, the cavitation bubble radius and the initial radius increase, and the cavitation intensity increases. That is, the higher the sound intensity, the stronger the cavitation, which is conducive to cleaning. However, it is not the greater the power, the better the cleaning effect, but the correct and reasonable selection of ultrasonic power.
2小功率偏差
2 small power deviation
声功率越高,空化效应越明显,产生大量无用气泡,变大衍射衰减,形成声屏障。同时,声强越高,非线性衰减越大,这将影响被清洗部件远离声源的清洗效果。另外,清洗振动板的空化腐蚀更为严重,导致设备寿命缩短。如果超声波清洗功率太小,会影响工件的清洗时间,清洗时间会更长,或者会偏离清洗效果。
The higher the sound power, the more obvious the cavitation effect, producing a large number of useless bubbles, increasing the diffraction attenuation and forming a sound barrier. At the same time, the higher the sound intensity, the greater the nonlinear attenuation, which will affect the cleaning effect of the cleaned parts away from the sound source. In addition, the cavitation corrosion of the cleaning vibrating plate is more serious, resulting in the shortening of the service life of the equipment. If the ultrasonic cleaning power is too small, the cleaning time of the workpiece will be affected, the cleaning time will be longer, or the cleaning effect will be deviated.
3功率选择
3 power selection
此,我们在选择超声波清洗设备时,一般工件高度都在30cm以下,那么选用的超声波清洗设备在槽高约40cm左右,选择底部单个振动板,功率保持在每平方厘米0.3~0.5w。如果工件太大,或者每次清洗量太大,我们选择的水箱高度在40cm以上,一般按功率上升计算,一般选择11W/L。
Therefore, when we select ultrasonic cleaning equipment, generally the workpiece height is below 30cm, so the selected ultrasonic cleaning equipment is about 40cm high in the groove, and a single vibrating plate at the bottom is selected, with the power maintained at 0.3~0.5w per square centimeter. If the workpiece is too large or the amount of cleaning each time is too large, the height of the water tank we choose is more than 40cm, which is generally calculated according to the power rise, and 11w/l is generally selected.
以上就是为大家介绍的超声波清洗机价格有关的详细的介绍,希望对您有所帮助.如果您有什么疑问的话,欢迎联系我们.我们将以专业的态度,为您提供服务.
The above is the price of ultrasonic cleaning machine I hope that the detailed introduction to the will be helpful to you If you have any questions, please contact us We will provide you with professional service

联系我们

詹老师:18663767799(微信同号)

陶老师:13011716033(微信同号)

张老师:18663767790(微信同号)

:1476171179/1500705758

:jnkergs@163.com

:地址:济南市先行区太平街道机械装备产业园创业路二号

关注科尔

  • 扫一扫了解更多

  • 扫一扫了解更多

备案号:鲁ICP备18049717号-1 技术支持:网站建设·推广运营